Online Publications

PDF file available

AGR-146

Using Animal Manures as Nutrient Sources

Monroe Rasnake, Bill Thom, and Frank Sikora

Animal manures can be an economical and effective source of crop nutrients. Land application of animal manures is also a Best Management Practice for protecting water quality when it is carried out properly. Correct land application of animal manures depends on the producer knowing:

This publication provides information on proper use of animal manures as nutrient sources for crops.

Nutrient Content

Nutrient content of manures varies, depending on the:

The best way to determine manure's nutrient content is to have manure samples tested as near the time of use as possible. In many cases, however, this is not practical or is nearly impossible to do. However, tabular values for the nutrient concentration of manure or the results of previous testing of similar manures can be used to determine application rates for good crop production and water quality protection.

Table 1 provides a good estimate of nutrient values of some manures available for use in Kentucky. These values should be used unless manure test results are available for the materials actually being used. Manure test data for a particular farm, either current or historical, will allow a more accurate calculation of available nutrients being applied, but Table 1 still should be used as a base reference.

Table 1. Nutrient content of manures commonly used in Kentucky. (All values on an "as-is" moisture basis.)
N P2O5 K2O Moisture (%)
Solid Manures (lb/ton)
Beef1171080
Dairy1191280
Swine99882
Broiler(fresh)55554520
(stockpiled)40803520
(cake)60704030
(pullet)40684025
(breeder)35553040
Layer30403040
Liquid Manures (lb/1,000 gal)
Holding PitSwine36272296
Dairy31151994
LagoonSwine42499
Dairy42398

It is often hard to obtain a representative sample of manures, so results that vary significantly from the values in Table 1 should be questioned. For guidelines on taking manure samples, see UK Cooperative Extension Service publication Livestock Waste Sampling and Testing (ID-123).

Availability to Crops

Some manure nutrients are not as readily available to crops as those in commercial fertilizers, especially nitrogen. Its availability to a crop depends on:

Table 2 lists nutrient availability situations most likely to occur on Kentucky farms.

Table 2. Percent nutrients from manure available to a crop for one year from the time of application. Percentages are availability coeffcients as compared to commercial fertilizers.
NutrientCropManagementPoultry or Liquid (%)Other Manures (%)
NitrogenCorn or Annual Grasses, Spring Applied2 days or lessa6050
3-4 daysa5545
5-6 daysa5040
7 or more daysa4535
Corn or Annual Grasses, Fall AppliedNo cover crop1520
Cover crop5040
Small GrainsApplied preplant5040
Pasture or Hay, Cool SeasonApplied in spring or fall8060
BermudagrassApplied spring or summer5040
Phosphate (P2O5)8080
Potash (K2O)100100
aIncorporation shown, referring to how long after application manure is mixed into the soil.

Nitrogen tends to be more readily available from poultry or liquid manures than other manures, primarily because these manures have a higher nitrogen-to-carbon ratio, which increases microbial activity. However, time of application and whether or not the manure is mixed with the soil are the most important factors in nitrogen availability. Growing crops have the greatest ability to take up nitrogen, so manure applied close to the time of maximum crop growth will have the least risk of nitrogen loss.

The most extreme example of low nitrogen availability shown in Table 2 is that of manure applied in the fall with no cover crop. In that case, only 15 to 20 percent of the nitrogen remains available for the next year's corn crop. Most of the nitrogen loss from applying manure in the fall could be prevented by growing a cover crop. A cover crop would take up nitrogen as it becomes available and release it as the cover crop decomposes and the corn crop grows. Manure applied to pastures of cool-season grass in fall or early spring has a high nitrogen availability because volatilization losses are less at these times of year. Nitrogen can be taken up by the grass all year as the nitrogen is released from the decomposing manure.

Mixing of manure with the soil—especially during warm weather—increases nitrogen availability to crops, which is reflected in the coefficients in Table 2 for spring-applied manure for corn. If the manure is not incorporated within seven days of application, the nitrogen availability coefficient decreases by 15 points. As little as ½ inch of rainfall after manure is applied also helps move nitrogen into the soil and prevent its loss. Excess rainfall, on the other hand, can cause nitrogen loss through runoff or leaching. The risk of nitrogen loss is small, however, unless manure is applied on soil that is already wet or frozen.

Unlike nitrogen, phosphate is not readily lost from manure and the soil, but the availability of manure phosphate to the first year's crop is somewhat less than that of fertilizer phosphate. For this reason, the phosphate availability coefficient of manure in Table 2 is set at 80. Potash in manure is comparable in availability to fertilizer potash and is given an availability coefficient of 100.

Carry-Over

Some of the nitrogen contained in manure is released slowly and becomes available in subsequent years. Significant amounts of this carry-over nitrogen can accumulate with frequent manure applications. Estimates of availability of carry-over nitrogen are shown in Table 3. This residual nitrogen should be taken into account by subtracting it from crop nitrogen recommendations when calculating a crop's nitrogen needs.

Table 3. Estimated available nitrogen from manure as percentage of manure nitrogen applied previous year.
Frequency of Annual Application over 10-Year PeriodPoultry or Liquid ManureOther Manures
< 435
4-8715
8 >1225
Source: D.B. Beegle, Penn State University.

Phosphate and potash from manure also can be held in the soil and carried over. They are not likely to be lost through runoff or leaching if good conservation practices are used. Instead, they stay in the soil and help build fertility for future crops. Phosphate and potash carried over from manure applied in previous years will be reflected in soil test results.

Calculating Manure Application Rates

The rates of manure application for a particular crop depend on:

The worksheet on the facing page can be used to calculate how much manure should be applied to provide the nutrient most needed by a crop. A balance sheet (Nos. 8 and 9 in the worksheet) also calculates nutrients that may need to be added from other sources.

An example calculation in the first column shows fresh broiler litter being used to provide the nitrogen needs of a corn crop. Fertilizer recommendations from soil test results call for 180 pounds of nitrogen, 70 pounds of phosphate, and 125 pounds of potash. No preplant fertilizer is used in the example, but 2 tons per acre of broiler litter would have been applied the previous year and in four out of the last 10 years. The litter is to be broadcast on the surface, and corn is planted no-till. The amount of manure required to supply the priority nutrient needed by the crop—in this example, nitrogen—is calculated.

Worksheet

CalculationsExampleYour Field
1.Crop to Be GrownCorn
2.Fertilizer Recommendation
a.Nitrogen (lb N/A)180
b.Phosphorus (lb P2O5/A)70
c.Potassium (lb K2O/A)125
3.Preplant Fertilizer
a.N0
b.P2O50
c.K2O0
4.Residual N from Manure (Unitsa of manure applied previous year x lb N/unit x availability coefficient--see Table 3)2T x 55 lb/T x .07 = 8 lb
5.Net Nutrient Needs
a.N (2a - 3a - 4)172 lb
b.P2O5 (2b - 3b)70
c.K2O (2c - 3c)125
6.Available Nutrients with As-Is Moisture in Manure (lb/unit)
a.N (lb N/unit) (Table 1 or test results) x available coefficient (Table 2)55 x .45 = 25
b.P2O5 (lb P2O5/unit [Table 1] x .8)55 x .8 = 44
c.K2O (lb K2O/unit [Table 1])45
7.Application Rate to Supply Priority Nutrient
a.Priority nutrientN
b.Amount needed (5a, b, or c)172
c.Manure needed (7b 6a, b, or c)172 25 = 6.9 T
8.Nutrients Supplied by 7c
a.N (7c x 6a)6.9 x 25 = 172
b.P2O5 (7c x 6b)6.9 x 44 = 304
c.K2O (7c x 6c)6.9 x 45 = 310
9.Additional Nutrients Neededb (-) = need; (+) = excess
a.N (8a - 5a)172 - 172 = 0
b.P2O5 (8b - 5b)304 - 70 = 234
c.K2O (8c - 5c)310 - 125 = 185
aUnits = tons, 1,000 gal, or acre inches, depending on the type of manure used (1 acre inch equals approximately 27,000 gal).
bThe example calculation shows that 6.9 tons of broiler litter per acre can supply all the nitrogen needed by the crop. However, an excess of 234 pounds of phosphate and 185 pounds of potash per acre is supplied by this much manure. These amounts will result in higher soil test levels of phosphate and potash. Repeated overapplication of phosphate could restrict the amount of manure that can be applied to a field in future years.

Dry manures can be transported and used economically some distance from where they are produced, but liquid manures cannot.

Dry manures accumulating inside grower houses are protected from rain, but they need to be stored properly once removed to prevent surface and ground water contamination.

Growing animals in large numbers leads to accumulation of manure that must be stored and used carefully to provide the maximum benefit to the farmer and minimum risk to the environment.


Equal opportunity statement